This recipe appears in:The Food Lab: How to Make Grilled Stuffed Flank Steak Pinwheels Grilled Stuffed Flank Steak With Pesto, Mozzarella, and Prosciutto
Grilling and pesto are two of the quintessential flavors of summer. Here we combine the two by slathering a butterflied flank steak with fresh pesto, then layering it with mozzarella and prosciutto before slicing it into pinwheels and grilling it over hot coals.
Why this recipe works:
- Butterflying the flank steak allows you to stuff it more easily. Butterflying with the grain ensures that the steak will be sliced against the grain into serving portions.
- Securing the rolled flank steak with a combination of butcher's twine and wooden skewers helps them hold together as they cook on the grill.
- We cook the steaks first over a hot fire to help the cheese and fillings build up a crust that will prevent them from leaking out when we then transfer the steaks to the cooler side of the grill to finish cooking, freeing up the hot side for vegetable sides.
About the author: J. Kenji Lopez-Alt is the Chief Creative Officer of Serious Eats where he likes to explore the science of home cooking in his weekly column The Food Lab. You can follow him at @thefoodlab on Twitter, or at The Food Lab on Facebook.
- 1 whole flank steak, 2 to 2 1/2 pounds, trimmed of excess fat
- Kosher salt and freshly ground black pepper
- 1 recipe Classic Ligurian Pesto
- 3/4 cup toasted pine nuts
- 3 ounces thinly sliced prosciutto
- 4 ounces thinly sliced low-moisture mozzarella cheese
- extra-virgin olive oil
Lay steak on a cutting board with grain running parallel to the edge of the counter. Trim left and right edges to form a clean rectangle and reserve scraps for another use. Hold steak flat with your non-knife hand and, with a sharp boning knife, carefully butterfly the steak, leaving the back edge attached by 1/2- to 1/4-inch of meat. Open up steak and flatten the seam gently with your hand to form a large perfect rectangle.
Season steak on exposed side with salt and pepper. Spread half of pesto evenly over steak, leaving a 1-inch border at the top and the bottom. Sprinkle with pine nuts. Layer prosciutto and mozzarella over steak, leaving the border at the top and bottom.
Carefully roll the steak away from you (the grain should run width-wise), tightening as you go until it is rolled into a cylinder. Let it rest with its seam-side down.
Tie the beef tightly with twine, spacing the ties evenly every 1 1/2 inches. Insert a skewer through each piece of twine. Using a sharp knife, carefully cut between the ties to make the pinwheels. Season with salt and pepper.
Light one chimney full of charcoal. When all the charcoal is lit and covered with gray ash, pour out and spread the coals evenly over half of coal grate. Alternatively, set half the burners of a gas grill to high heat. Set cooking grate in place, cover gill and allow to preheat for 5 minutes. Clean and oil the grilling grate. Place the pinwheels on the hot side of the grill and cook without moving until well charred on first side, about 3 minutes. Flip steaks and char second side, about 3 minutes longer. Transfer to cooler side of grill, cover, and cook until an instant read thermometer inserted into the center registers 120°F for medium-rare or 130°F for medium. Transfer to a platter, let rest for five minutes, and serve with remaining pesto and a drizzle of olive oil.