Note: Herbs and aromatics can be substituted or altered according to taste. I find it easiest to work with a whole belly at a time and if a smaller roast is desired, to split it in half and freeze half while still raw. Wrapped tightly in foil and plastic wrap, it should last for several months in the freezer. Thaw overnight in the refrigerator and proceed with cooking steps as instructed. To cook with potatoes, cut 4 pounds russet potatoes into 2-inch chunks and boil in salted water until just tender, about 10 minutes. Drain and set aside. Add to roasting pan in the middle of step 6, tossing them with the pig's drippings to coat. Continue roasting the porchetta with the potatoes in the pan. Turn the potatoes with a spatula every 45 minutes or so as they roast.
If you're using a rimmed baking sheet and still want to roast potatoes, you can pour off the drippings in the middle fo step 6, toss them then the par-boiled potatoes, then place the potatoes on a separate rimmed baking sheet in a rack below the porchetta. Turn the potatoes every 45 minutes or so as they roast.
About This Recipe
|Yield:||12 to 15|
|Active time:||2 hours|
|Total time:||1 day|
|Special equipment:||Roasting pan with V-rack or rimmed baking sheet with metal rack, butcher's twine|
|This recipe appears in:||From the Archives: Porchetta, the Ultimate Holiday Roast The Food Lab Redux: 7 Pork Dishes for the Holidays The Food Lab: How to Make All-Belly Porchetta, the Ultimate Holiday Roast|
- 1 whole boneless, rind-on pork belly, about 12 to 15 pounds
- 2 tablespoons whole black peppercorns
- 3 tablespoons whole fennel seed
- 1 tablespoon crushed red pepper
- 3 tablespoons finely chopped rosemary, sage, or thyme leaves
- 12 cloves garlic, grated on a microplane grater
- Kosher salt
- 2 teaspoons baking powder
Place pork belly skin-side down on a large cutting board. Using a sharp chef's knife, score flesh at an angle using strokes about 1-inch apart. Rotate knife 90 degrees and repeat to create a diamond pattern in the flesh.
Toast peppercorns and fennel seed in a small skillet over medium-high heat until lightly browned and aromatic, about 2 minutes. Transfer to a mortar and pestle or spice grinder and grind until roughly crushed.
Season pork liberally with salt then sprinkle with crushed pepper and fennel, red pepper, chopped herbs, and microplaned garlic. Use your hands to rub the mixture deeply into the cracks and crevices in the meat.
Roll belly into a tight log and push to top of cutting board, seam-side down. Cut 12 to 18 lengths of kitchen twine long enough to tie around the pork and lay them down in regular intervals along your cutting board, about 1-inch apart each. Lay rolled pork seam-side down on top of strings. Working from the outermost strings towards the center, tie up roast tightly. Combine 2 tablespoons kosher salt with 1 teaspoon baking powder. Rub mixture over entire surface of porchetta.
If roast is too large and unwieldy, carefully slice in half with a sharp chef's knife. Wrap tightly in plastic and refrigerate at least overnight and up to three days. If desired, porchetta can also be frozen at this point for future use (see note)
Adjust an oven rack to the lower-middle position and preheat oven to 300°F. Place pork in a v-rack set in a large roasting pan, or if cooking both halves at the same time, on a wire rack set in a rimmed baking sheet. Place roasting pan in oven and roast until internal temperature of pork reaches 160°F, about two hours, basting with pan drippings every half hour. If you'd like to cook potatoes along with the porchetta, see note. Continue roasting until a knife or skewer inserted into the pork shows very little resistance asides from the outer layer of skin, about two hours longer.
Increase oven temperature to 500°F and continue roasting until completely crisp and blistered, about 20 to 30 minutes longer. Alternatively, you can remove the roast from the oven and tent with foil for up to two hours before finishing it in a preheated 500°F oven.
Tent with foil and allow to rest for 15 minutes. Slice with a serrated knife into 1-inch thick disks and serve.